Tech Tips

ARCHIVE= D=20 TECH TIPS =BB

CURRENT TECH=20 TIP =BB

Tech Tip 185: 03/31/06 - = Maintenance Checklist

The following general checklist of = maintenance=20 items is not all-inclusive. Your model RV may require additional = regular=20 maintenance practices. For more detailed information, consult the=20 operator's manual. Start and drive the motor home a minimum of 20 = miles=20 each month. Operate the generator while driving down the road. =

Chassis:

1. Lubricate all chassis = fittings.=20

2. Change engine oil and filter.

3. Change transmission oil and filter. =

4. Rear end oil change.

5. Fuel filters changed.

6. Inspect or change air filter.

7. Replace hydraulic filter.

8. Clean charge air cooler and = radiator.

9. Check engine coolant level.

10. Check belts and hoses for wear or = cracking.=20 Remove dust and debris build up.

11. Check tires pressure.

12. Check for oil leaks (engine, = hydraulic,=20 coolant).

13. Inspect and adjust brakes.

14. Drain air tanks =96 front and rear. =

15. Replace air dryer filter. =

Electrical System =96 Chassis = and House:=20

1. Regularly maintain both = the=20 chassis and house batteries. Inspect liquid lead acid battery = cells and=20 keep filled with distilled water to 1/8 inch below the vent = tube. Do not=20 overfill the battery. Frequently clean liquid lead acid and AGM = battery=20 cases to remove corrosion and inspect cables for tightness. =

2. Check all exterior lights =96 brake = lights, turn=20 signals, back-up camera, clearance lights, head lights (low and = high=20 beam).

3. Inspect shore cord connections for = tightness.=20 Straighten the cord to uncoil kinks. Clean the cord to remove = dust and=20 debris. Burnt or discolored prongs may need to be replaced.=20

Equipment:

1. Lube and clean entry = steps.=20 Inspect for worn parts.

2. Remove bathroom and kitchen ceiling = fan=20 screens. Wash screens in mild soap and water. Rinse with clear = water and=20 thoroughly dry before reinstallation.

3. Lube pocket door rollers two times = per year.=20

Appliances:

1. Clean the refrigerator = interior=20 box to wipe up spills. Go to the outside vent and remove insect = nests,=20 dirt and debris.

2. Wash microwave filters to remove = grease build=20 up.

3. Vacuum the remote temperature = sensors for the=20 wall thermostats.

4. Wash roof A/C filters =96 there may = be up to=20 three of them in the motor home.

5. Wipe clean furnace or Aqua-Hot. = Inspect and=20 change filters as needed.

Water System:

1. Remove and clean all = drain=20 screens on faucets.

2. Remove and clean screen on water = pump.

3. Remove and replace water filters. =

4. Check air pressure in the = accumulator tank (if=20 equipped).

5. Check waste drain hoses for leaks = and hose=20 clamps for tightness.

6. Lubricate the knife valves on the = gray and=20 black tank dump valves using a small amount of silicone. =

Exterior Roof:

1. Wash roof every other = time you=20 wash the sidewalls.

2. Inspect roof sealant for cracks and = replace as=20 needed.

3. Clean solar panel (if equipped). =

4. Open awnings and wash away dust and = debris=20 buildup.

TOP

=A92006 Monaco Coach = Corporation. All Rights=20 Reserved.